Maiden Voyage of the Aeromods.

Let’s review the aeromods the truck gained over the winter:

Remember this shnizzle winter project? My aero-upgrades: enclosing the wheel wells and center plate.
Adding vortex generators making entangled-air-current providing “clean air” under the truck, and filling all air gaps with black tight-cell foam held in place with rare-earth magnets.
Vortex generators to stabilize airflow at the front wheels.
Magnetic/removeable vortex generators that I created at the line of the windshield (I also placed them forward of the rear-view mirrors), and Air-Tab vortex generators along the rear line of the shell, and a stubby radio antenna.

The drive to Montana has “varying terrain and conditions”. 5 mountain passes of varying thousands of feet elevation gain and drop, portions of 80mph interstate, and 65 & 70mph blue highway. Conditions include wind/gale lasting hundreds of miles from singular or varied direction- so a tailwind has given the unmodified supercharged truck it’s maximum expected mileage of 17mpg on the 65-70mph sections, while it usually runs at around 15mpg in still air. A supercharged engine gives maximum performance at all times, running at a matching RPM to Speed; the only variance is how much gas it takes to maintain that speed. At 80mph mileage plummets; with a tailwind getting around 13mpg, and with a headwind 11 mpg. I was expecting an at-best improvement of around 5%, which is what adding a super-sloped aero-shell can do; essentially the shape of the Tesla Truck.

The best mileage by manufacturer is 17mpg, boosted to a best now of 20mpg: 17% gain. This means 1/3 less stops for gas, or down to two 15 gallon stops for a 19 gallon tank instead of 3 stops (vs an improbable best mileage two- fill-up trip with 16/18 gallon fill-ups with the fuel light on, sometimes for tooooo long). One less stop for gas shaves about 1/2 hour off the trip, our best time ever in the past for this route was 9 hours. This past trip, with a bit of holiday weekend traffic 100 miles in and out of Yellowstone’s west gate, was 9.5 hours, and would have been 10 hours. Along with shorter time and less fuel, is the amazing stability at speed. There is no sense of sidewind/headwind push, no semi-trailer blow-by, with exceptional in-line tracking and much lower cab noise. This is due in part to stabilizing the nose of the truck by reducing lift from the high/open Shrockworks bumber, but also due to Fluid Entrainment provided by the vortex generator AirTabs along the rear line of the shell. The amount of horsepower available is greatly increased: sailing easily over all the mountain passes, and the ability to jump to passing speed is a bit giddying. A big debate is out there on supercharged engines vs turbocharged engines, and I now I know the advantage of no turbo-lag when punching it at speed: which is also a safety issue, just at the higher end of performance. (special thanks to Julian Edgar for aerodynamic modification discussions on you-tube)

Salt Lake City to Idaho Falls with 20mph+ headwind: 210 miles at 80 mph / 15 gallons : 14mpg. Old/11 to now/14 = 27% improvement. . 400# load in bed, plus two adults, one dog, three cats. (capacity is 900#)

Idaho Falls to White Sulphur Springs: 278 miles at 65-70mph / 15.3 gallons : 18mpg. Usual Old/15 to now/18 = 20% Lighter headwind and 400# load

Return trip with 250# load, same passengers, and still air through the first half of trip, with tailwind later. Lets see: Monarch to Bozeman: 140 miles at 65-70mph / can’t give straight number as filled up in Great Falls and drove around the ranch, but it looked like 20 mpg?. nutz. can’t be right.

Bozeman, MT to McCammon, ID: 270 miles / 15gal = 18mpg. (65mph/144miles, 70mph/53miles, 80mph/74miles). Usual Old/ 15mpg to Now/18mpg = 20%. Best Old/17 to Now/18 = 5% At the end of the 65mph zone we guestimated 20mpg, and best to best mileage of 17 v 20 is 17% gain, normal to now is 15 v 20 @ 33% gain. McCammon is the farthest ever travelled on a tank of gas from Bozeman. Usually we stop in Idaho Falls <74 miles prior>, and ONCE with a strong tailwind the entire way we made it to Pocatello <51 miles past ID Falls>.

McCammon, ID to SLC, UT: 140 miles @ 80mph (mostly)/ 9 gallons : 15.5mpg with tailwind. Best Old/13mpg to Now/15.5mpg = 19% (half tank remaining, we usually get home with the fuel light just coming on, a 1/4 tank at best, or having had to fill up outside Ogden).

How does all this mpg play out at Blue Highway speeds? Best Old (17) to Avg Now (18) @ 5%. Avg Old (15) to Avg Now (18) @ 20%. Avg. Old (15) to Best Now (20) @ 33%

How does all this mpg play out on 80mph Interstate? Headwind Old (11) to Headwind Now (14.5) @ 31%. Tailwind Old (13) to Tailwind Now (15.5) @ 19%.

Leave a Reply

Fill in your details below or click an icon to log in:

WordPress.com Logo

You are commenting using your WordPress.com account. Log Out /  Change )

Google photo

You are commenting using your Google account. Log Out /  Change )

Twitter picture

You are commenting using your Twitter account. Log Out /  Change )

Facebook photo

You are commenting using your Facebook account. Log Out /  Change )

Connecting to %s

This site uses Akismet to reduce spam. Learn how your comment data is processed.